Capital IdeasSM

Investment insights from Capital Group

Categories
Global Equities
The aviation industry: Five reasons for resilience
Todd Saligman
Analyste d’investissement actions

Last year was a truly awful time for global aviation. The COVID-19 pandemic brought about the biggest disruption to the global aviation industry in its entire history.


To Todd Saligman, Capital Group aviation analyst, the numbers are still mind-blowing.


“Putting 2020 into historical context gives a sense of just how bad the decline in aviation volume demand was: Global air travel fell 65% in 2020. Before last year, the worst decline in history was 3% and that had occurred only three times.”1


Nevertheless, despite the magnitude of events, there are several reasons why some sectors within aviation, such as aircraft manufacturing, may be more resilient than they have been in the past.


Aviation has been a fairly stable secular growth industry over the past four decades and the declines seen in 2020 were 20 times worse than the previous worst year in history1. Given the extraordinary fall in air traffic, it’s obvious why it was such a painful year for stocks in this industry.


Air traffic witnessed a ‘10 standard deviation’ event, but is expected to eventually recover to attractive long-term growth


Annual growth in commercial air travel ‘volume’ demand (revenue passenger kilometres flown)


Estimates shown for illustrative purposes only.
As at 31 December 2020. Sources: IATA, Goldman Sachs
GDP: gross domestic product



However, what is interesting about the sharp fall in air traffic is that we didn’t see aircraft production fall to the same extent. This is especially striking given the cyclical nature of the industry, historically.


Even before the COVID-19 crisis emerged, Todd had been advocating the view that the aerospace industry is structurally different from the past. The chart below shows the cyclicality of aircraft production rates historically; rising significantly then falling significantly. And, despite the large declines in production rates in 2020 due to COVID-19, his view is that 2020 actually illustrated how structurally different the industry is compared with in previous downturns.


“Production rates in the mid-1990s and early 2000s dropped 40% to 50% when travel volumes declined only 2% to 3% in any given year. However, last year, when travel declined by a massive 65%, production rates fell across the industry by ‘only’ 30% to 40% – and a big part of that was due to 737 MAX safety issues rather than COVID-19.”2


Aircraft production cyclicality has vastly reduced over the past two decades


Annual commercial aircraft deliveries


This information has been provided solely for informational purposes and is not an offer, or solicitation of an offer, or a recommendation to buy or sell any security or instrument listed herein. Estimates shown for illustrative purposes only.
As at 31 December 2020. CAGR: compound annual growth rate. Sources: Boeing, Airbus, Bank of America, Goldman Sachs, Capital Group


 


So, while the huge decline in traffic was still very painful, it actually showed the industry is less cyclical than it was 20-30 years ago. Production rates since the early 2000s have been much more stable. Todd cites a number of reasons why that’s the case.


1. More diversified demand


Demand for aircraft is much more diversified today.


• Growth and replacement demand: Historically, most aircraft deliveries were a response to industry growth. Today, it is more evenly split, with about 60% of new planes accounting for fleet growth and 40% for replacement of older planes.2 An important characteristic of replacement demand is that it is less cyclical than growth demand.
• Geographic demand: Previously, the industry was much more dependent on the fate of airlines in the US and to some extent in Europe, but today it’s a global industry. It is therefore less dependent on any one region, which also adds stability that wasn’t there in previous years.


 


2. Bigger backlogs


Aircraft manufacturing is essentially a global duopoly between Airbus and Boeing. Before the crisis, the long-term structural demand for their products meant backlogs on their order books were much larger than they had been in the past. While there has been a considerable number of unfilled orders for Boeing and Airbus because some airlines didn’t take deliveries due to the impact of COVID-19, looking at the bigger picture there are still huge backlogs and great demand for aircraft. The size and robustness of the order books brings stability and visibility to revenues from original equipment manufacturers (OEMs).


 


3. Production planning


Another difference today compared with 20-30 years ago is that production is now planned more cautiously. Previously, production rates would increase very quickly in response to orders. Over the past decade, Boeing and Airbus have both been disciplined about raising production rates gradually to avoid periods of significant oversupply, which helps reduce cyclicality.


 


4. Period of less development


The industry is currently in a period of less development compared to the past. Both Boeing and Airbus have spent billions of dollars over the past 10-15 years developing new aircraft. Development projects are expensive and contain a level of risk. But development cycles are also long, so if there were plans to launch new models before 2030, development work would already be underway. While there will likely be tweaks to current aeroplane models, such as adding functionality, Todd doesn’t think there will be any clean sheet development programmes in the near-to-medium term, certainly for Airbus. Boeing is arguably in greater need to build a new aircraft shorter term, but whether it does or not will depend on how the company responds to the challenge it faces with its 737 MAX aircraft3. Nevertheless, over the next 10 years the number of development projects will be much lower than in the past, which helps companies’ margins and returns.


 


5. Efficiency gains support replacement demand


An appetite for new-generation aircraft has kept order cancellations relatively low. When compared to the past two decades, 2020 doesn’t stand out as a particularly bad year in terms of order cancellations, despite the level of uncertainty. Cancellations were a little over 1,500 globally last year, representing about 10% of the total order book backlog.4 And most of those were for Boeing aircraft (Airbus cancellations were minimal) and were likely caused by the 737 MAX safety issues.


Order cancellations are encouragingly low, driven by appetite for new generation aircraft


Cancellation of aircraft orders


As at 31 December 2020. Sources: Redburn, Cirium


 


One reason for this resilience relates to Todd’s point on the economics of replacement demand. New aeroplanes today are between 15% and 20% more fuel-efficient than the previous generation. That represents a two-generation leap in terms of efficiency. In the past new aircraft offered fuel efficiency improvements of about 5%-8% on the previous model.5


Fuel costs will differ depending on the airline, but these efficiency gains have a significant impact on airlines’ margins. If we use an approximation for the industry that fuel accounts for 22% of an airline’s costs and operating profit margins are 5%; assuming all other costs are constant, reducing fuel costs by 15% means that airlines’ profit margins improve from 5% to 8%. This is a 60% increase – just by replacing older planes with newer, more fuel-efficient models.5 So even if airlines didn’t want to take new planes on to expand their fleets, it still makes economic sense to replace older aircraft.


Newer aircraft variants offer lower fuel costs, lower emissions and higher margins for airlines


Profit breakdown: newer vs. current engine aircraft


For illustrative purposes only
As at 8 February 2021. Representative example only, assuming fuel efficiency gains of 15% and an oil price of US$65 per barrel. Source: Goldman Sachs Investment Research


 


1. As at 31 December 2020. Sources: IATA, Goldman Sachs


2. As at 31 December 2020. Sources: Boeing, Airbus, Bank of America, Goldman Sachs, Capital Group


3. Production of Boeing’s 737 MAX aircraft was reduced after the US Federal Aviation Administration (FAA) grounded the aircraft in March 2019, pending a safety investigation.


4. As at 31 December 2020. Sources: Redburn, Cirium


5. As at 8 February 2021. Representative example only, assuming fuel efficiency gains of 15% and an oil price of US$65 per barrel. Source: Goldman Sachs Investment Research


 



Todd Saligman est analyste d’investissement actions chez Capital Group, chargé de couvrir les secteurs américains et européens de l’aéronautique, de la défense et des compagnies aériennes, ainsi que le secteur américain des croisières. Il possède 12 ans d’expérience et a rejoint Capital Group il y a 8 ans. Il est titulaire d’un MBA de Harvard Business School et d’une licence d’économie (avec mention d’excellence) de l’université de Pennsylvanie. Todd est basé à Los Angeles.


 

Past results are not a guarantee of future results. The value of investments and income from them can go down as well as up and you may lose some or all of your initial investment. This information is not intended to provide investment, tax or other advice, or to be a solicitation to buy or sell any securities.

Statements attributed to an individual represent the opinions of that individual as of the date published and do not necessarily reflect the opinions of Capital Group or its affiliates. All information is as at the date indicated unless otherwise stated. Some information may have been obtained from third parties, and as such the reliability of that information is not guaranteed.